Measure and mark 4 inches on your piece of wood using a tape measure and speed square. | Open the rip fence by pulling the red lever up and slide it to four inches away from the saw blade. | Under the table there is a wheel with a nut in the middle of it. Unscrew the nut and turn the wheel to change the blade depth. |
Turn the wheel to be about one centimeter above the wood. Make sure to tighten the bolt again before continuing on. | Once you are ready to cut flip the switch on and wait until it is solid green and not red and green flashing. This just turns on the power to the table. | Be sure that your wood is flat against the rip fence away from the blade. Pull the big red stop switch towards you and the blade will turn on. Slowly move your piece through the saw all the way until the wood is fully cut. Then press the big red button to stop the blade. |
Once you have your long piece of wood, mark 2 4.5“x4” and 2 10“x4”. | Then get the sled and slide it onto the table saw. It will sit in the grooves so it should only move forwards and backwards, not side to side. Next pull the sled all the way towards you, put the wood on top and readjust the blade height (revisit previous steps in necessary). | Line up the marks perpendicular to the slice in the sled. Lining this up well is important otherwise your cuts will not be exactly what you wanted. |
Turn on the saw and hold the sled with your palms starting on the side with the start button and hold the sled down firmly with your figures out of the way, but still holding down the wood. Run the wood through until you can see the blade all the way through the sled. Keep your body and face away from the blade! | Repeat so you have all four pieces you measured and marked. Next you are going to cut a thin piece of plywood (1/8“) into a 4 3/4” x 10“ rectangle (this will be your base of your box). | Take the sled off the table and move the rip fence to be about 1/2” of the blade and lower it so that the blade is half the thickness of the plywood. |
| | |
Move the rip fence over 1/8 of an inch until and run the wood through again. Run the wood through until the piece of plywood can easily slide in, but make sure there is not too much wiggle room. | Run the all the wood through until you get the groves that fit the plywood well. Should take about two times. | Once the wood is all cut, put the wood in corner clamps lining up the grooves perfectly. Have two corner clamps so you can glue two sides separately. Use wood glue to glue it together. |
Once the glue is dried slide the thin plywood into the grooves and seal up the box using more glue. Then you have your box! | Final Box! | |